3198 Effect Of Quarry Dust As Partial Replacement Of Fine Aggregate In Concrete

Experimental Study on Concrete and Cement Plaster Using ...

Experimental Study on Concrete and Cement Plaster Using Partial Replacement of Quarry Rock Dust as Fine Aggregate Golagani Aruna1 D. Srinivasrao2 1M.Tech Student 2Assistant Professor 1,2VITAM College of Engineering, Visakhapatnam, Andhra Pradesh, India Abstract—Conventional Cement Concrete (CCC) consists

Learn More

EXPERIMENTAL INVESTIGATION ON PARTIAL …

evaluate the possibilities of using quarry dust as a replacement to fine aggregate with an aim not to lose the strength far from original concrete mix. . During the present study, 10%, 20%, 30%, 40%, 50% and traditional fine aggregate is replaced with quarry dust. Compressive strength

Learn More

What are the advantages of partial replacement of fine ...

Feb 06, 2017· Reduction of cost and utilisation of waste materials. Sand is becoming extremely expensive now. Materials such as artificial sand are being introduced into the market at large scale that reduce the cost burden of river sand on concrete considerabl...

Learn More

STUDY ON STRENGTH AND DURABILITY OF CONCRETE BY …

efficient disposal. Hence, partial or full replacement of fine aggregates by the other compatible materials like sintered fly ash, crushed rock dust, quarry dust, glass powder, recycled concrete dust, and others are being researched from past two decades, in view of conserving the ecological balance.

Learn More

EFFECT OF QUARRY DUST AS PARTIAL REPLACEMENT OF SAND IN ...

The effect of quarry dust on the flexural strength of concrete has been experimentally studied and reported in this paper. Concrete used was prepared by replacing 25% and of sand by weight ...

Learn More

The Utilization of Quarry Dust as Fine Aggregates in Concrete

and suitability of the use of quarry dust for the partial replacement of sand in concrete. In the tenure of the study, the authors determined some important parametric properties of quarry dust. Also cubes for the partially replaced concrete of size 150mm x 150mm were casted, cured and then tested for the compressive strength.

Learn More

Studies on Quarry Dust as Partial Replacement of Fine ...

to use Quarry dust to replace the fine aggregates in concrete. Following are some of the conclusions drawn from the results of this investigation: 1. Quarry dust can be used as a finer material which can reduce the voids in concrete. 2. Up to 20% replacement of fine aggregates by quarry dust, the results obtained are satisfactory. 3.

Learn More

Effect of Partial Replacement of Fine Aggregate with ...

Effect of Partial Replacement of Fine Aggregate with Artificial Sand - written by Mr. M. Vijay, Mr. S. Satheeshkumar, Mr. N. Muthu Selvakumar published on 2018/04/24 download full article with reference data and citations

Learn More

GGBS and Fine Aggregate with Quarry Dust Concrete by ...

strength characteristics of concrete by partial replacement of cement with GGBS and Fine aggregate with Quarry Dust for application in structural concrete, which will give better understanding on the properties of concrete. The effect of GGBS and Quarry Dust (QD) on the properties of Concrete are studied. 3. Experimental Programme

Learn More

A Study on the Partial Replacement of Coarse and Fine ...

A Study on the Partial Replacement of Coarse and Fine Aggregate by Coconut Shell and Quarry Dust DOI: 10.9790/1684-1404076369 www.iosrjournals.org 65 | Page Physical properties of coconut shell aggregate Table 2: Results of Tests on coconut shell Aggregate S.

Learn More

Partial Replacement of Cement with Quarry Dust and Rice ...

quarry dust. This disposal of marble powder from the marble industry is of environmental problem today. Then the used for replacement process 25 grade concrete. The partial replacement of mix design of concrete. As percentage replacement of 20%, 25%, 30% are used in marble powder and quarry dust increases for workability reduce. The

Learn More

(DOC) EFFECT OF QUARRY DUST AS PARTIAL REPLACEMENT OF …

Quarry dust is a waste obtained during quarrying process. It has very recently gained good attention to be used as an effective filler material instead of fine aggregate. Also, the use of quarry dust as the fine aggregate decreases the cost of concrete production in terms of the partial replacement …

Learn More

Study on Compressive Strength of Quarry Dust as Fine ...

The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries. By replacement of quarry dust, the requirement of land fill area can be reduced and can also solve the problem of natural sand scarcity. The availability of sand at low cost as a fine aggregate in concrete is not suitable and ...

Learn More

Effects of The Total and Partial Replacement of Sharp Sand ...

Previous research carried out on this shows positive results and hence quarry dust has very recently gained good attention to be used as an effective filler material instead of sharp sand. This project will investigate the effect of the total and partial replacement of sharp sand with quarry dust on concrete.

Learn More

Effect of Partial Replacement of Fine Aggregate with ...

Effect of Partial Replacement of Fine Aggregate with Artificial Sand Mr. M. Vijay1 ... Strength And Durability Properties Of Concrete Containing Quarry Rock Dust As Fine Aggregate, ARPN Journal of Engineering and Applied Sciences, vol. 3, no. 5. ... strength properties of concrete. ,Effect,of,Partial,Replacement,of,Fine,Aggregate,with ...

Learn More

Experimental Study on Use of Quarry Dust and Fly Ash with ...

aggregates. In this experimental study an attempt will be made to find the effect of partial replacement of Fine aggregate by Quarry Dust and Cement by Fly ash. The innovative use of Quarry Dust in concrete formulations as a fine aggregate replacement in the range of 0%, 15%, 30% & 45% by weight for M-40 grade cement (PPC).

Learn More

Partial Replacement of Sand by Quarry Dust in Concrete

investigated the partial replacement of sand with quarry dust. Initially cement concrete cube was studied with various proportions of cement concrete + quarry dust (M 20, AND M25). The experimental results showed that the addition of quarry dust as fine aggregate ratio of 30%, 40% and 50% was found to enhance the compressive properties.

Learn More

Suitability of Quarry Dust as Partial Replacement Material ...

This project is an experimental investigation into the effect of using quarry dust with iron filing as a partial replacement for fine aggregates [sand] in concrete production.

Learn More

INVESTIGATING THE EFFECTS OF THE REPLACEMENT OF SAND …

Quarry dust is a waste obtained during the quarrying process. Quarry dust has very recently gained good attention to be used as an effective filler material instead of sand. The use of quarry dust as a fine aggregate decreases the cost of concrete production in terms of the complete replacement and even partial replacement of natural river sand.

Learn More

Partial Replacement of Fine Aggregates with Quarry Dust ...

Quarry dust and Marble powder are the most used among such materials to replace river sand, which can be used as alternative to fine aggregate in concrete. In the present investigation workability and strength of concrete was evaluated by replacement of natural sand by Quarry dust and marble powder in equal proportions of 0%, 10%, 20%,

Learn More

Behaviour of Concrete on Replacement of Sand with Quaries ...

1. For the designed mix proportions of M25 and M40 grades of concrete the desired characteristic strengths for cubes are achieved in both conventional concrete and Quarry Stone dust concrete. 2. The strength achieved in concrete made with sand as fine aggregate achieved high strengths when compared with Quarry stone dust concrete.

Learn More

STUDY OF PARTIAL REPLACEMENT OF FINE AGGREGATE …

compressive strength and split tensile strength of concrete with quarry dust as a partial replacement of fine a ggregate, the following conclusion can be drawn: 1. The compressive strength of concrete is i use of quarry dust up to 10% replacement of sand. F rom 10% there is …

Learn More

Quarry Dust as a Partial Replacement of Coarse Aggregates ...

Karthicket al (2014), in his study on the usage of quarry dust as a partial replacement for sand in concrete found that the compressive strength of concrete cubes at 28 days of curing was improved as high as 35.26% above the strength of conventional concrete when 40% of the fine aggregate was replaced with quarry dust by weight.

Learn More

An Experimental study on Effects of Quarry Dust as Partial ...

50% replacement of sand by quarry dust gives higher compressive strength than natural sand concrete. Key Words: Concrete, quarry dust, river sand, compressive strength, replacement. 1.INTRODUCTION The motive of this study is to determine the effect of quarry dust in concrete as fine aggregate to finding an

Learn More

Partial Replacement of Sand by Quarry Dust in Concrete

The paper describe the role of quarry dust In the construction of buildings and other structures to eliminate the demand of natural sand by using quarry waste to replace the use of natural sand. We are investigating the potential of using quarry

Learn More

Strength properties of concrete by partial replacement of ...

Title: Strength properties of concrete by partial replacement of cement with silica fume and fine aggregate, Author: Editor IJAERD, Name: Strength properties of concrete by partial replacement of ...

Learn More

Effect of quarry rock dust on the flexural strength of ...

The flexural strength of concrete made with quarry dust as fine aggregate is higher (about 4.3%) than conventional river sand concrete. 2. The 10–15% rule of thumb was found to be applicable in the estimation of flexural strength of quarry-sand concrete based on its compressive strength. 3.

Learn More